Posted: Wed Nov 06, 2013 11:15 am Post subject: M38 Slow battery drain?
I have a 52' 24 volt refurbished to original specs M38.. My batterys tend to slowly go down. I have just installed 2 - 12v trickle chargers on each battery. It s parked at my deer camp so i use it best every other week. Would rather address the problem.......any ideas on where to start? thanks _________________ 1952 M38
1-Current leaking through a switch or accessory.
Standard troubleshooting means isolating one circuit at a time with a test lamp between the disconnected battery ground cable and the negative terminal of the battery closest to ground. As long as the lamp glows you have a leak to ground. When the lamp goes out you have finally disconnected the offending circuit/component. The usual culprit is a corroded or burned contact/s on the start switch.
2-Two batteries with non-conforming state of charge or potential.
This happens when you only replace one battery and now you have one tired older battery and one healthy new battery. When two dissimilar potential batteries are connected in series they become involved in a see-saw run down event where one chases the other until both are discharged.
If you do a search for the term battery you will find a dozen or more posts on this topic! _________________ Wes K
45 MB, 51 M38, 54 M37, 66 M101A1, 60 CJ5, 76 DJ5D, 47Bantam T3-C & 5? M100
"test lamp between the disconnected battery ground cable and the negative terminal of the battery closest to ground. "
trying to grasp the above scenerio....so disconnect neg ground to frame..... then clip light to neg ground on frame and touch the lamp to the closet unhooked neg pole on the closet batery? _________________ 1952 M38
Joined: Apr 23, 2012 Posts: 67 Location: Sun City, Az.
Posted: Thu Nov 07, 2013 7:19 am Post subject: M38 slow battery drain
I though to mention how I have handled this issue. After loosing 2 6v batteries on my 46 CJ (thru the key/coil switch) I now make it a practice to disconnect the negative terminal (I stick it on firmly) when not using the jeep. A manufacturer told me that a disconnected battery should maintain its charge (stands to reason). I continued to do this on my M38, disconnecting the negative terminal going to ground on frame. TIP: On my M38 I installed a switch that I purchased at an RV store (heavy duty) which turned the negative cable aforementioned off and on. I mounted it thru the fender well ahead of the right front tire which was adjacent to the negative cable going to the frame. It protruded about an inch and was painted 24087. (hardly noticeable) There is a red plastic key which is used to actuate. This also made it impossible to actuate the ignition from the normal switch on the dash. (theft proof) _________________ regor
1951 M38 #23945
Joined: Apr 23, 2012 Posts: 67 Location: Sun City, Az.
Posted: Thu Nov 07, 2013 7:24 am Post subject:
Wes, what is that little question mark in the little blue box under my name and the word member in my post? thanks! _________________ regor
1951 M38 #23945
It indicates you have not selected a photo or emblem to appear under your name.
Regor,
The battery guy who told you they won't discharge if the terminal is disconnected is not entirely correct. The batteries will not discharge through the offending circuit any more but they can still discharge themselves several ways.
1-If left unclean with acid deposits across the battery case you can provide a circuit between the - & + terminals which will discharge the battery.
2-Flooded lead acid batteries will not hold their original charge over several years since there is always a very minute amount of internal discharging that occurs.
3-When two or more batteries are connected in series then as they age and their potential deteriorates at different rates they eventually will chase each other down as in a see saw affect. _________________ Wes K
45 MB, 51 M38, 54 M37, 66 M101A1, 60 CJ5, 76 DJ5D, 47Bantam T3-C & 5? M100
Joined: Apr 23, 2012 Posts: 67 Location: Sun City, Az.
Posted: Thu Nov 07, 2013 12:16 pm Post subject:
That makes sense, thanks Wes. I should have mentioned also that I keep
1 1/2 amp. battery minders on all my batteries (except the 6v, cause I haven't found one) _________________ regor
1951 M38 #23945
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot vote in polls in this forum